Chemgineer
Hazard to Others
Posts: 216
Registered: 25-5-2021
Member Is Offline
|
|
Essential oil purification
If I do a soxhlet extraction of mint leaves using ethanol it obviously also extracts the chlorophyll and other stuff. Is there an effective way to
isolate the essential oil afterwards?
I've tried steam distillation but seem to get very low (almost none existent) yield.
|
|
|
UC235
National Hazard
Posts: 565
Registered: 28-12-2014
Member Is Offline
Mood: No Mood
|
|
Essential oil yields are incredibly low no matter what you do. At most, you can get a few % of the starting material's weight. This is highly
dependent on what part of the plant you're distilling, cultivar, harvest time, weather, etc.
Some strongly scented herbs only contain a fraction of a percent of essential oil. Complicating the matter is nonzero water solubility which leads to
a lot of hydrosol and little essential oil. A receiver that allows you to recycle the lower layer of distillate into the stillpot will improve yield.
You can also saturate the hydrosol with salt and extract with low-boiling organic solvents to recover it.
[Edited on 19-3-2023 by UC235]
|
|
|
Elking_around
Harmless
Posts: 9
Registered: 23-1-2023
Member Is Offline
|
|
Following your steam distillation, centrifuging the hydrosol can be an effective way to separate your essential oil from it. You could also try
solvent extraction with DCM I suppose.
[Edited on 19-3-2023 by Elking_around]
|
|
|
Fery
International Hazard
Posts: 1015
Registered: 27-8-2019
Location: Czechoslovakia
Member Is Offline
|
|
There is also a lot of menthol dissolved in water phase. Distill water phase again to obtain more menthol, you can distill off only small part of
water from it which carries most of the dissolved menthol into second distillate.
I always do 2 distillations, first one from big still and in the second one from lab glass RBF.
https://www.sciencemadness.org/whisper/viewthread.php?tid=15...
https://www.sciencemadness.org/whisper/viewthread.php?tid=15...
|
|
|
pneumatician
Hazard to Others
Posts: 411
Registered: 27-5-2013
Location: Magonia
Member Is Offline
Mood: ■■■■■■■■■■ INRI ■■■■■■■■■■ ** Igne Natura Renovatur Integra **
|
|
Is the oil rancid??
|
|
|
![[*]](images/xpblue/default_icon.gif){kind=icon}
