Pages:
1
2
3
..
5 |
ADP
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 120
Registered: 4-4-2005
Location: USA
Member Is Offline
Mood: Productive
|
|
Capsaicin extraction and isolation
Quote: | from Wikipedia:
The chemical compound capsaicin (C18H27NO3) (8-methyl-N-vanillyl-6-nonenamide) is the active component of chile peppers (Capsicum). It is an
irritant for mammals including humans and produces a sensation of burning in the mouth. Capsaicin and several related compounds are called
capsaicinoids and are produced as a secondary metabolite by certain plants of the genus Capsicum (chile peppers), probably as deterrants against
herbivores. Pure capsaicin is a lipophilic colorless odorless crystalline to waxy compound.
|
Some of the properties of this compound include a molecular mass of 305.41 g/mol and a melting point of 62 - 65°C. I'm not sure of solubilities of
this compound but believe that is it soluble in ethanol and in oils. I want to try an extraction. Basically I believe that I can reflux dried red
pepper seeds in ethanol and filter in filter paper while hot. The filtrate I can boil down and crash with water (assuming capsaicum is insoluble in
water) to recover the waxy crystals of capsaicin.
Does this method seem like it would work? Any suggestions?
|
|
The_Davster
A pnictogen
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 2861
Registered: 18-11-2003
Member Is Offline
Mood: .
|
|
I gave it a shot a few weeks back using only 2 really hot homegrown chillies. Used acetone and ground dried hot pepper in acetone, mag stirring for
8h. I got a bright red solution which I filtered of pepper parts and left the acetone to evaporate. I was left with a small ammount of red ooze in
the bottom of the beaker. Seeing as there was so little of it I decided to flush it, and while I was washing the beaker a small particle must have
become airborne which I preceeded to breathe in. YOWEE![:D](./images/smilies/biggrin.gif)
Be carefull
I plan on growing some Red Savina this summer so I can give capsaicin extraction another try. Ideally I want to end up with a white crystalline
product.
http://www.rowan.edu/biology/faculty/obrien/GBPP.Hot%20Peppe...
The hard part is separating the capsaicin from the capsiacinoids
[Edited on 13-2-2006 by rogue chemist]
|
|
BromicAcid
International Hazard
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 3237
Registered: 13-7-2003
Location: Wisconsin
Member Is Offline
Mood: Rock n' Roll
|
|
There is one nitrogen atom there that might help to facilitate an acid/base type reaction. I was personally thinking about doing the same extraction
by coincidence a few weeks ago, I like my food hot and the food suppliers that sell "Pure Cap" charge quite large sums of money, I find it strange
that the brand "Pure Cap" has a scoville rating of only 500,000 (I say 'only' as a relative comparison) the hottest sauce that I was able to
find has a rating of 16,000,000 Here is a good site:
http://www.sweatnspice.com/hottest_sauces.php
So yeah, extracting my own capsaicin could save me $$$ considering the hottest sauces sell for over $200 for small amounts.
|
|
12AX7
Post Harlot
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 4803
Registered: 8-3-2005
Location: oscillating
Member Is Offline
Mood: informative
|
|
Considering an Habanero is around 250k Scovilles, you'll need to concentrate it roughly 100x, i.e., 1% yield at best. Which I suppose isn't bad in
regards to plant yields, depending on your point of view.
If you've been cooking much (surely you have! ), you'll note the heat always
concentrates in the fat. I'd go for a lipophilic solvent; paint thinner (mineral spirits) might work nicely if you don't intend on eating it (I
should hope not, at that strength ). That might evaporate a bit slowly, so heck,
alcohol or acetone probably work fine. How about say, ether, ordinary or petroleum type?
And you're right, an alkaloid extraction might well do something. Seems to me with all the hydrocarbon hanging off, you'd end up with something like
a fricking spicy detergent, though!
Tim
|
|
The_Davster
A pnictogen
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 2861
Registered: 18-11-2003
Member Is Offline
Mood: .
|
|
I want some capsaicin for cooking purposes as well, so as non-toxic a method as possible is of course. I plan on starting with a large number of
peppers and doing the extraction with some everclear or the most concentrated drinking grade alcohol possible to get the red oil of capsaicin and
capsaicinoids, for most cooking purposes the oil is likely fine, or perhaps better as each capsaicinoid has its own type of burn, so a mix would give
a much nicer, broader burn.![:D](./images/smilies/biggrin.gif)
Separating them via acid/base extraction I would think would be complicated by the fact that it is an amide nitrogen and too much/too hot base could
break up the amide bond. I have no experiance with the acid/base extraction of amides(only ever done amines), so I might be rambling....
Kind of off topic but...
Quote: |
Maybe rogue chemist has fondness for cajun food , three alarm chili , and slices onions with a smile You know the sort that eats hot peppers like they were celery sticks , peppers which would be lethal to the average
person |
Now how did rosco predict my fondness for spicy food before I ever acquired a tase for them....
|
|
Darkblade48
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 411
Registered: 27-3-2005
Location: Canada
Member Is Offline
Mood: No Mood
|
|
Quote: | Originally posted by BromicAcid
... the hottest sauce that I was able to find has a rating of 16,000,000 |
What's weird is that from my source, pure capsaicin has a rating of 16 million Scoville units (it wasn't a sauce)
|
|
BromicAcid
International Hazard
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 3237
Registered: 13-7-2003
Location: Wisconsin
Member Is Offline
Mood: Rock n' Roll
|
|
Hence why sauce was in ittalics. It was crystals of the pure capsaicin but it is sold on that hot sauce site. Pure capsaicin is scary, a crystal on
the skin supposedly causes destructive damage, I couldn't imagine what a crystal in the mouth would be like. Scary like boiling drain cleaner scary,
right up my alley.
[Edited on 2/13/2006 by BromicAcid]
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
I would love to have pure capsaicin, but even if there is an easy method of extracting it, I don't think I would do it... Not without an astronaut
suit. It will blister your skin on contact and can stop breathing. Nasty stuff.
I did however, make a very strong habanero oil:
I chopped 1lb. of orange habs into small peices and dehydrated in an oven on the lowest setting.
I then crumbled them up into a powder, placed into a 400mL beaker and topped it off with isopropanol.
Then I gave it a mad stirring, let it sit, followed by another mad stirring.
I poured the now orangeish liquid through a coffee filter to yield a very nice looking bright orange liquid.
I placed the beaker on a hot plate and evaporated most of it, then using an eyedropper I filled up a ~1mL vial with the concentrated dark red solution
and placed it onto the hotplate.
Everytime the vial had more room I would add more drops of the dark red capsaicinoid solution into it to top it off.
I did this until all the liquid from the 400mL beaker was gone.
My yield was about (i'm guessing here) 0.5mL of very dark red, very thick oil that hardens in the fridge.
This stuff is unbelievably hot! I dip the very end of a toothpick into the surface of the oil (nowhere near a drop's worth) and it will heat up my
entire mouth and my ears will tingle and i'll be suffering nicely ![:P](./images/smilies/tongue.gif)
I have some Pure-Cap and I can honestly say that it is like tap water compared to this stuff I made.
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
Here are some pics displaying its viscosity. I store it in the fridge, and when it warms up becomes a viscous oil, as you can see in the "Upside down
with drip."
|
|
Chris The Great
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 463
Registered: 29-10-2004
Location: Canada
Member Is Offline
Mood: No Mood
|
|
Quote: | Originally posted by BromicAcid
Scary like boiling drain cleaner scary, right up my alley. |
Well I'm sure that would spice up your food as well, and be far cheaper. Other alternatives could be lewisite (mustard gas wouldn't work, since you'd
eat the food and only get the 'spicy' until a few hours later). Perhaps an application of tear gas would spice it up (anyone tasted chloropicrin?).
On a more on topic note, pepper spray should yield large amounts of the desired chemical with a simple extraction. Might be cheaper than a crate of
super-hot peppers. From what I've seen it is up to 10% capsaicin depending on the brand.
|
|
unionised
International Hazard
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 5109
Registered: 1-11-2003
Location: UK
Member Is Offline
Mood: No Mood
|
|
Since the nitorgen in capsaicin is in an amide I think it won't be very basic. By the time you have a strong enough acid to protonate it, hydrolysis
will set in.
I think a major part of the problem with purification would be removing the fats from the extract. If I wanted to do this I might try chromatography.
|
|
chemoleo
Biochemicus Energeticus
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 3005
Registered: 23-7-2003
Location: England Germany
Member Is Offline
Mood: crystalline
|
|
There's a presentation I once did on a variety of 'taste' receptors, which included capsaicin, whose action is sensed by heat receptors. Essentially,
capsaicin mimics the action of heat, similar to menthol mimicking the action of cold.
Attached are excerpts of that presentation. It's also got the original reference (some nature paper), where the extraction of capsaicin is described.
If you want I can dig out that paper at a later time.
Attachment: capsaicin.pdf (427kB) This file has been downloaded 3908 times
Never Stop to Begin, and Never Begin to Stop...
Tolerance is good. But not with the intolerant! (Wilhelm Busch)
|
|
Flip
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 116
Registered: 7-12-2005
Member Is Offline
Mood: No Mood
|
|
Oleoresin capsaicin
I remember hearing from a salesman that the hottest peppers you can find will still only be in the range of 5000 Scoville units... police strength
pepper spray on the other hand is around 2,000,000 Scoville heat units. I'm not sure if the oleoresin is what you're after, but this might be a
source.
|
|
Ramiel
Vicious like a ferret
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 484
Registered: 19-8-2002
Location: Room at the Back, Australia
Member Is Offline
Mood: Semi-demented
|
|
Perhaps a little light can be shed on extraction with he following anecdote:
Probably the most pain I've been in <i>in my life</i> apart from shattering a bone into pieces (just to give you a reference) was from
eating some leftover Chinese food. It was a "chilli & tomato omelette" (obviously with some rice) dish which had been made in the morning and left
to sit in it's oily putrescence under heat-lamps in a little plastic container for hours on end. The omelette was fine, just a little bit of hot
coming from the dried chillies (~ 5-7 cm long, deep red - very common I think) - countered pleasantly with the sweet tomato. I got to the bottom and
saw that after finishing all the rice and then omlette, a single red chilli had escaped, along with a puddle of oil (I assume vegetable oil of the
cheapest brand)... given how much I enjoyed the meal and not thinking too much about the chemistry of what I was doing, i scoffed the whole lot
down... started chewing...
Let me relate to you the sensations for science’s [read:humour’s] sake, and to demonstrate how I come to my conclusion?
Okay; Immediately, a pleasant warm sensation: thinking "wow, that's nice and hot"... "Yea, really hot, I wonder if I can actually finish this? Better
start to chew it up! " *chew* *chew* *chew*... at this point the subject
realises that something is amiss, the eyes start to water, mouth starts to burn, the skin on my head starts to crawl, the <i>outside</i>
of my face and lips start to burn… 5 seconds later, salivary glands go hawire, cough and gag reflex starts to kick in, eyes watering too badly to
see five yards ahead. Subject spits out the offending matter – too late, mouth is burning with an industrial quality, very acrid and blistering
sensation, breathing becomes laboured wheezing amongst coughs… I stumble to the nearest toilet and vomit (I hope we are all being scientific at this
time and not smirking!). This goes on for a good five minutes while the subject consumes litres of water and gargles desperately with any chemically
active mouthwash/foodstuff he can think of. Pain. Agony!
I realised that at the end of the ordeal (and I have come to call it that) that I was crying, not out of any tearing reflex, but out of pain, hatred
and self pity. I’m not a big cryer, having cried perhaps 5 times in my adult life… this was certainly one of them.
So I concluded that most of the capsaicin from all of the chillies was extracted in the organic vegetable oil, due to the mild nature of the eaten
chillies (with seeds) and the contrasting EVIL of the oil vis uneaten chilli (or “Rambo chilli” as I have come to call him). Recall that they were
simply cooked in oil, then put in a closed container with heat (kept above 60*C as per hygiene regulations) for 4-7 hours. I should like to repeat the
experiment under controlled conditions tonight, and will get back to you, since vegetable oil is a food friendly solvent. I suppose we’ll all know
by tomorrow whether I’m just a pansy, a <i>silk shirted sissy</i>, or a simple idiot.
Thankyouforyourtime
Ramiel
Caveat Orator
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
I vote for sissy .
I remember a friend who ate a whole chile from some unknown Mexican plant in his front yard. He dropped to his knees, claiming he could barely
breathe. A while later (after more chiles eaten) he ate one without too much fuss. He did have to go get water though.
Back then I could barely eat a tiny chunk of a habanero, but now I can pop one in my mouth and chew it to a fine consistency and swallow without too
much of a spectacle, and no water until the burning stops.
I think you're just not used to capsaicinoids yet. The oil in your mouth surely didn't help, but give it time and practice...
|
|
Ramiel
Vicious like a ferret
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 484
Registered: 19-8-2002
Location: Room at the Back, Australia
Member Is Offline
Mood: Semi-demented
|
|
Naw, I conducted the "extraction" with a few different oils.. one was a cheap as chips "sunola" oil (which I suspect the resteraunt to have used),
then olive oil, then plain "black and gold vegetable oil" (okay, so I'm a cheap student). The sunola oil <i>seemed</i> to work the best.
After heating some chopped chillies in the oven (closed container) for a few hours, the sunola was clearly the spiciest of the oils, while all of them
definitely had a little warmth in them.
My father is a sadist, he dared me to eat a tablespoon of tobasco when I was a wee three years old. From this harsh upbringing, I have learnt to love
chillies, and am rarely bothered by them, but what really shocked me regarding the above experience were the <i>involuntary</i>
physiological responses.
I suspect that if you heated the sunola oil/chopped chilli mix you’d get a very favourable extraction of capsaicin in an edible medium.
Caveat Orator
|
|
kazaa81
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 368
Registered: 30-4-2004
Member Is Offline
Mood: ok
|
|
Some capsaicin data...
Here is some capsaicin data, from Handbook of Chemistry and Physics 85th edition.
Capsaicin
C18H27NO3
CAS #: 404-86-4
Mol. 305.412 g/mol
Form: monoclinic plates or scales (from petroleum ether)
M.P. 65°C
B.P. 215^0.01°C
Insoluble in H2O;
very soluble in EtOH;
soluble in diethyl ether, benzene, petroleum ether;
slightly soluble in concentrated HCl;
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
Lol. When I was three, I don't think I knew what a dare even was!
Extraction with oils would only work for food, and it would only be medium spicy. (Don't get me wrong - I'm comparing it to the IPA extraction I did).
I too am a sucker for those involuntary physiological responses. I start to hiccup like crazy, then my eyes start dripping like a faucet. Even when
it's not too hot.
|
|
Nerro
National Hazard
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 596
Registered: 29-9-2004
Location: Netherlands
Member Is Offline
Mood: Whatever...
|
|
In response to kazaa81, If one were to distill cheap wodka something in the region of 80% EtOH and (pretty much) 20% water would be obtained. Grind
the chiles, put them in the "wodka" under gentle reflux with good stirring for a few hours, filter and then crash in icecold water. That should
precipitate a lot of the capsaicin right?
[Edited on Wed/Mar/2006 by Nerro]
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
Wrong. There definately would be capsaicin in it, but chiles have many capsaicinoids that are alcohol soluble. Which capsaicinoids and in what ratio
depends on what type of chile you're using. There also would be other oils from the chiles that might crash out too. You wouldn't end up with a
crystalline capsacin product.
|
|
Nerro
National Hazard
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 596
Registered: 29-9-2004
Location: Netherlands
Member Is Offline
Mood: Whatever...
|
|
I meant dried chiles, and if it's for food purposes that means you want all the capsainoids.
[Edited on Thu/Mar/2006 by Nerro]
|
|
lordmagnus
Hazard to Self
![*](images/xpblue/star.gif)
Posts: 92
Registered: 10-1-2006
Location: Webster, TX
Member Is Offline
Mood: No longer annoyed ( I found a new girlfriend)
|
|
I remember watching something on TV about Capsaician extraction, the absolute pure kind is a fluffy white powder, they have to wear overpressure suits
(think the nuclear reactor scene in James Bond "Docotor NO"). The pure stuf can be like nerve gas, and kill with just a few flakes, this is diluted
down and made into those topical pain medications, although I think spraying MACE onthe injury would be cheaper and just as effective.
I\'ll kill a man in a fair fight, or if I think he is gonna start a fair fight, or if he\'s bothrn me allot, or if I am getin payed good, or probably
over a good woman.
-Jayne Cobb (Serenity)
|
|
innervision
Harmless
Posts: 49
Registered: 6-2-2006
Member Is Offline
Mood: eh.
|
|
Quote: | I meant dried chiles, and if it's for food purposes that means you want all the capsainoids. |
Soaking dried chiles in alcohol won't give pure capsaicinoids + alcohol.
If it's for food, then why would you want crystals. Trying to kill someone? For food, you would have to redissolve them in a LOT of something, so why
even go as far as to obtain crystals? Not even the most chile-tolerant person on the planet could take a sprinkle of capsaicin on his food.
I did try the crashing in ice water thing with saturated IPA. The water just turned orange/brown.
|
|
densest
Hazard to Others
![*](images/xpblue/star.gif) ![*](images/xpblue/star.gif)
Posts: 359
Registered: 1-10-2005
Location: in the lehr
Member Is Offline
Mood: slowly warming to strain point
|
|
A long long time ago on USENET the subject of capsaicin came up. According to a neurobiologist who posted, capsaicin is a neurotoxin. It first
irritates the substance P neurons, causing pain. More of it disables the neurons, causing "tolerance" of capsaicin. Most of the time, the neurons
regrow or recover, causing the loss of tolerance. The disabling of pain neurons is the behavior exploited in the capsaicin pain cream. Very potent
stuff!
A possible food-grade extraction process would be to grind chiles in food-grade vegetable oil or (gasp!) lard, then extract the oil with more volatile
solvents. The pigments in the chiles are less soluble in oil than the capsaicin.
|
|
lordmagnus
Hazard to Self
![*](images/xpblue/star.gif)
Posts: 92
Registered: 10-1-2006
Location: Webster, TX
Member Is Offline
Mood: No longer annoyed ( I found a new girlfriend)
|
|
Actually Capsaicin interfeers with the P-substance in neurons that transmit pain, but like I was saying in a previous reply, the absolutly pure stuff
is handeled in the overpressure suits to protect the workers, it's like nerve gas at that purity..
I\'ll kill a man in a fair fight, or if I think he is gonna start a fair fight, or if he\'s bothrn me allot, or if I am getin payed good, or probably
over a good woman.
-Jayne Cobb (Serenity)
|
|
Pages:
1
2
3
..
5 |