| Pages:
1
2 |
iloveloli
Harmless
Posts: 21
Registered: 8-8-2015
Member Is Offline
Mood: No Mood
|
|
how to extract pure nicotine ???
i read a lot of nicotine extraction is just forming ejuice
can i extract nicotine using DCM or other organic solvent
then using HCl gas to form nicotine-HCl
nicotine-HCl is easier for me to weight out how much i need
|
|
|
unionised
International Hazard
Posts: 5128
Registered: 1-11-2003
Location: UK
Member Is Offline
Mood: No Mood
|
|
Do you know just how dangerous nicotine is?
This sort of device delivers doses of 1 mg.
Can you weigh that small a mass accurately?
|
|
|
gatosgr
Hazard to Others
Posts: 237
Registered: 7-4-2015
Member Is Offline
Mood: No Mood
|
|
The estimated lower limit of a lethal dose of nicotine has been reported as between 500 and 1000 mg.
It passes through your skin.
[Edited on 9-4-2016 by gatosgr]
|
|
|
Increasing Wordiness
Harmless
Posts: 7
Registered: 9-4-2016
Member Is Offline
Mood: No Mood
|
|
Just perform a A/B extraction, first you have to cut the leaves and reflux it with aq. HCl. Then you have a water soluble alkaloid. Evaporate under
reduced pressure by destillation, the concentrated residual solvent is then treatment with a cold NaOH solution and add DCM in a seporatory funnel.
Keep the 2 layers for 6 hours in the funnel.
The DCM layer is dried in a erlenmeyer flask with dried MgSO4 while stirring for 30 min.
Evaporate the DCM layer and handle this toxic oil (nicotine) with care.
The LD50 is high and a oil that have a relative high vapour pressure.
Take Care.
Other methods are available too. Column chromatography (HPLC),...
>I don't know the starting material.<
|
|
|
phlogiston
International Hazard
Posts: 1379
Registered: 26-4-2008
Location: Neon Thorium Erbium Lanthanum Neodymium Sulphur
Member Is Offline
Mood: pyrophoric
|
|
If you are intending to vape it, consider that your extract will probably contain some impurities that may be even worse for your health then nicotine
itself, such as tobacco-specific nitrosamines.
Nicotine solution is not that expensive and online sellers are easy to find these days.
-----
"If a rocket goes up, who cares where it comes down, that's not my concern said Wernher von Braun" - Tom Lehrer |
|
|
Mailinmypocket
International Hazard
Posts: 1351
Registered: 12-5-2011
Member Is Offline
Mood: No Mood
|
|
Is this about extracting nicotine from e-liquid or from tobacco leaves?
Anyways, this is german but can be translated:
http://lambdasyn.org/synfiles/nikotin.htm
Note to self: Tare the damned flask.
|
|
|
Fegie
Harmless
Posts: 17
Registered: 6-4-2016
Member Is Offline
Mood: No Mood
|
|
Quote: Originally posted by phlogiston  | If you are intending to vape it, consider that your extract will probably contain some impurities that may be even worse for your health then nicotine
itself, such as tobacco-specific nitrosamines.
Nicotine solution is not that expensive and online sellers are easy to find these days. |
This reminds me of crocodil, its not the drug itself that fucks you up, its the traces of solvents used, most likely the same thing would happen here
too..
|
|
|
aga
Forum Drunkard
Posts: 7030
Registered: 25-3-2014
Member Is Offline
|
|
Personally i just light the cigarette, suck, and my 'body' amazingly isolates nicotine and applies it to the brain-parts it was intended for.
Surprisingly it also seems to deal favourably with the 100+ other combustion/partial-pyrolysis products at the same time.
Nictotine addicts should either give it up (as i do, every night while i sleep) or simply not take nicotine.
Cigarette, Cigar, Vape, Nicotine patch, inhaler etc etc - you're still an addict, still Using.
|
|
|
Varmint
Hazard to Others
Posts: 264
Registered: 30-5-2013
Location: Near Atlanta, GA
Member Is Offline
Mood: No Mood
|
|
Aga:
This is true (still an addict) but nicotine has enough positive effects that I'm certain there will be ongoing use, especially for vaping.
Nicotine is not a carcinogen, the danger comes from the myriad of toxic compounds that piggyback the two main delivery mechanisms of burning and
chewing.
I have a friend who smoked two packs of filtered cigarettes a day, he had a chronic cough, his skin was aging at a hugely accelerated rate, in
general, he looked and sounded like hell. For decades.
He switched to vaping about 3 years ago, since then his cough has disappeared, his skin is recovering more of a tone bereft his age, and he says he
feels better now than he did at any age since his late teens.
My point is, so long as you are comfortable labeling yourself an addict, why not take a very much lower risk approach and vape instead of smoke?
Just looking out for you, if I hadn't seen Tim's health improve I would never have believed it.
Take care.
|
|
|
aga
Forum Drunkard
Posts: 7030
Registered: 25-3-2014
Member Is Offline
|
|
He'd look and feel better if he gave up entirely.
Stat.
Can't guarantee the 'look' part.
My point is that Nicotine is a Highly addictive drug.
A Smart and Determined Mind can kick that addiction, and live longer, and healthier.
Feck. Now i got to Quit or remain a dumb-ass.
Good. Thanks for the Impetus.
|
|
|
Increasing Wordiness
Harmless
Posts: 7
Registered: 9-4-2016
Member Is Offline
Mood: No Mood
|
|
This is indeed the right procedure for the extraction and determination of the quantity and quality.
Steam distillation with 5% NaOH until 1,5 L is collected in the receiver flask. I don't have Congo red as pH indicator, methyl orange or other pH
indicators might also work to enable the determination.
There is enough time to calculate the EP: the exact mass of oxalic acid (and their pKa values) and the pKb of nicotine already know along with the
total volume. Which is a good exercise... in the non smoking lab. 
Nicotine is a dark yellow to yellow brown hygroscopic oil that is volatile, avoid skin contact and don't use it as recreational substance as it
block certain ion channels and act as nerve poison. I do remember that it was used as insecticide but now it's replaced by less toxic molecules.
Since nicotine is miscible in water and very soluble in chloroform, diethyl ether, pure EtOH it might explain why my method didn't
work. Also, the starting material is important: if the dried leaves of Nicotiana tabacum are used then the yield is higher.
|
|
|
pepe
Harmless
Posts: 35
Registered: 5-6-2016
Location: Memeisland
Member Is Offline
Mood: REEEEEEE
|
|
I have a bit of a strange question pertaining to nicotine extraction. As we know nicotine can be delivered to the body via inhaled smoke. What would
be the possibility of burning an amount of tobacco in a controlled environment with an apparatus to collect the smoke then doing an acid base
extraction on the settled smoke?
I know this is an odd and silly question as you would have to burn quite a large amount of tobacco to collect any usable amount of smoke but this is
more a thought experiment rather than an actual proposition.
|
|
|
phlogiston
International Hazard
Posts: 1379
Registered: 26-4-2008
Location: Neon Thorium Erbium Lanthanum Neodymium Sulphur
Member Is Offline
Mood: pyrophoric
|
|
That is not at all an odd or silly question!
What you describe is in fact the very method used by Tobacco research laboratories worldwide to verify the nicotine content of the smoke of
cigarettes, as specified in ISO 10315 (analysis of nicotine in smoke condensates )and ISO 3308 (the smoking machine)
IIRC the smoke from 20 cigarettes is collected on each filter, and the nicotine is extracted from the filters with hexane.
The ISO protocols specify exact conditions and methods by which the cigarettes are conditioned and smoked such as duration, volume, profile and
interval of puffs, the air humidity, temperature, ventilation etc. etc.
[Edited on 6-6-2016 by phlogiston]
-----
"If a rocket goes up, who cares where it comes down, that's not my concern said Wernher von Braun" - Tom Lehrer |
|
|
UC235
National Hazard
Posts: 565
Registered: 28-12-2014
Member Is Offline
Mood: No Mood
|
|
It would be a terrible way to isolate the nicotine from the plant matter. A large portion of it is destroyed on burning. The goal of using such a
setup to quantify nicotine is to figure out how much nicotine is delivered by smoking each cig.
|
|
|
Romix
Hazard to Others (Literally)
Posts: 483
Registered: 19-6-2015
Member Is Offline
Mood: No Mood
|
|
Is there any in burned sig filters?
Once, I soaked some in IPA to use for hydroponics as starting point, still have brown solution somewhere.
Could it be extracted from there?
[Edited on 1-7-2016 by Romix]
|
|
|
Romix
Hazard to Others (Literally)
Posts: 483
Registered: 19-6-2015
Member Is Offline
Mood: No Mood
|
|
Pyrolysing rest plant matter, would nicotine or salt distill over at 300 - 400C or decomposse?
|
|
|
Romix
Hazard to Others (Literally)
Posts: 483
Registered: 19-6-2015
Member Is Offline
Mood: No Mood
|
|
K in soluble part of ash, rest soluted in acid yellowy green.
Could be rust that mixed in
[Edited on 1-7-2016 by Romix]
|
|
|
urenthesage
Hazard to Self
Posts: 77
Registered: 21-2-2016
Member Is Offline
Mood: No Mood
|
|
| Quote: Originally posted by gatosgr | The estimated lower limit of a lethal dose of nicotine has been reported as between 500 and 1000 mg.
It passes through your skin.
[Edited on 9-4-2016 by gatosgr] |
Where did you get that???You confusing MICROGRAMS for MILLIGRAMS. the LD50 for nicotine is 0.8mg/kg. Thats not even one MILLIGRAM. a gram could kill
off 15 people.
[Edited on 4-7-2016 by urenthesage]
|
|
|
tandpasta
Harmless
Posts: 30
Registered: 13-10-2014
Member Is Offline
Mood: No Mood
|
|
This guy took over 5 grams and only died after 64 hours: http://www.sciencedirect.com/science/article/pii/07364679919...
That LD50 of 0,8mg/kg is a rough estimation based on cases where someone has ingested far more than that. It's hard to say what the LD50 for humans
actually is.
This paper cites an estimated LD50 of 1-10mg/kg: http://www.intljourtranur.com/article/S0099-1767(15)00127-0/abstract
So that 500-1000mg estimate isn't that weird.
|
|
|
gatosgr
Hazard to Others
Posts: 237
Registered: 7-4-2015
Member Is Offline
Mood: No Mood
|
|
| Quote: Originally posted by urenthesage | | Quote: Originally posted by gatosgr | The estimated lower limit of a lethal dose of nicotine has been reported as between 500 and 1000 mg.
It passes through your skin.
[Edited on 9-4-2016 by gatosgr] |
Where did you get that???You confusing MICROGRAMS for MILLIGRAMS. the LD50 for nicotine is 0.8mg/kg. Thats not even one MILLIGRAM. a gram could kill
off 15 people.
[Edited on 4-7-2016 by urenthesage] |
I copied it from wikipedia. The thing is that it passes through your skin so if you get two drops of nicotive on your clothes and don't realise it
well...that's why they don't sell pure nicotine unless you have a license.
|
|
|
feacetech
Hazard to Others
Posts: 163
Registered: 12-2-2007
Member Is Offline
Mood: No Mood
|
|
aga
I started e-cigs 2 years ago instead of smoking
it better than smoking once you get use to it and my health is way better
I don't cough (even when sick now).
I get sick less often.
Its heaps cheaper.
if I smoke a cig now it doesn't even work I am so used to getting vap through my nose.
100% vg
24mg/mL
1.2-1.5 ohm coils
Naturally extracted tobacco flavour
regulated battery.
On topic just get a good set of scales and weigh the nicotine solution and dilute.
I wouldn't try extract it yourself and then vap it.
|
|
|
Romix
Hazard to Others (Literally)
Posts: 483
Registered: 19-6-2015
Member Is Offline
Mood: No Mood
|
|
| Quote: Originally posted by gatosgr | | Quote: Originally posted by urenthesage | | Quote: Originally posted by gatosgr | The estimated lower limit of a lethal dose of nicotine has been reported as between 500 and 1000 mg.
It passes through your skin.
[Edited on 9-4-2016 by gatosgr] |
Where did you get that???You confusing MICROGRAMS for MILLIGRAMS. the LD50 for nicotine is 0.8mg/kg. Thats not even one MILLIGRAM. a gram could kill
off 15 people.
[Edited on 4-7-2016 by urenthesage] |
I copied it from wikipedia. The thing is that it passes through your skin so if you get two drops of nicotive on your clothes and don't realise it
well...that's why they don't sell pure nicotine unless you have a license. |
No, it's not, squeezed filters naked handed, still alive!
|
|
|
feacetech
Hazard to Others
Posts: 163
Registered: 12-2-2007
Member Is Offline
Mood: No Mood
|
|
spilt 24 mg/mL on my skin a lot
had 24mg/mL directly in my mouth several times
no ill effects or even noticeable effects (I weigh 80kg)
I always remember how they said nicotine was super toxic back in high school and how one drop in your mouth would drop you dead
looks like it was propaganda to me
[Edited on 11-7-2016 by feacetech]
|
|
|
clearly_not_atara
International Hazard
Posts: 2799
Registered: 3-11-2013
Member Is Offline
Mood: Big
|
|
24 mg/mL (propylene glycol) is about 2.4% by volume nicotine, or 1:40. So you'd have to drink 40 drops of this (nasty, oily, burning) liquid (which is
2 mL) to equal "one drop in your mouth" of pure nicotine.
How much nicotine is that, you might ask? Well, (40 drops) * (24 mg/mL) / (20 drops / mL) = 48 mg of nicotine, which is pretty close to the accepted
human LD50 of 50 mg. For context, a cigarette delivers 1-2 mg of nicotine, usually on the low end. In other words, yes, a drop of pure nicotine will
kill you, or can at least.
But propylene glycol is pretty bad at carrying things through the skin. It's an excellent hydrogen bond donor and acceptor, so PG liquid has high
cohesion and does not diffuse easily into polymer matrices like the human epithelium. A similar concentration of nicotine in DMSO would be far more
bioavailable by transdermal routes, hence far more dangerous to spill. In general, laboratory solvents are more like DMSO than PG, precisely because
the hydrogen-bonding and autoionization tendencies of PG make it a poor reaction medium (it's "sticky") unlike aprotic solvents. Even ethanol is much
better at penetrating skin than PG, although this effect is diminished markedly by the presence of water.
[Edited on 11-7-2016 by clearly_not_atara]
[Edited on 11-7-2016 by clearly_not_atara]
|
|
|
feacetech
Hazard to Others
Posts: 163
Registered: 12-2-2007
Member Is Offline
Mood: No Mood
|
|
I use VG (which doesn't really matter) (1 drop weighs 53.4 mg which doesn't really mean much either)
I can vape several mL in quite a short time (route of administration is nasal on the exhale (53% available))
according to wiki oral has the lowest bio availability 20-45% vs skin at 68%
I still say the LD50 is off and its no where nearly as toxic as it has been stated in the past.
Dog Franke & Thomas 1932 oral 9.2 mg/kg
Mouse Lazutka et al. 1969 oral 3.34 mg/kg
Rat Sine 1993 oral 50 mg/kg
look at the inter species variation, the 50-60mg human oral data is derived from the 1969 rat data.
wiki did have some human data 10g being fatal via stomach and injection and that nausea and vomiting from even low doses make ingestion difficult to
die from (you are right it does burn a bit in the mouth)
And the next question is do addicts develop tolerance?
|
|
|
| Pages:
1
2 |
![[*]](images/xpblue/default_icon.gif){kind=icon}
